Power Steering Recall

Roughly two years ago, Chrysler recalled approximately 442 Dodge Ram pick up trucks for a problem with the electric power steering (EPS) module.  The recall applied specifically to 2015 -2016 Ram 1500 trucks manufactured between January 22, 2015 and September 13, 2015.  The problem had to do with short circuiting of the EPS circuit board that would cause the loss of power steering and increase the risk of a crash.  Since that recall was put in effect, reports have been received that indicate that the short circuit is not enough to cause the 100 amp fuse, that is supposed to protect the module, to open.  As a result, the short circuits are causing wiring to overheat and ignite resulting in vehicular fires.  It should be noted that overheating of the wiring has not been addressed and is not part of the original recall.  The original recall is identified as NHTSA campaign # 16V16700 and Chrysler recall # S19.  A copy of the recall is attached below.  The second page shows a wiring diagram and the connection between the EPS module and battery through the 100 amp fuse that is in question.  Also shown is the connection between the battery and the power center.  If a fire occurs, the origin appears to be in the area of the battery and power center, both of which are located on the driver’s side of the engine compartment above the left front wheel well.  Complaints regarding vehicular fires related to this recall should be reported to NHTSA through their website at www.nhtsa.gov.

Recall & wiring diagram0001

Recall & wiring diagram0002

Advertisements
%d bloggers like this: